Performance Specifications

Engine                                                                                                                                                     

• Deutz BF6MI013E diesel operating at 2400 RPM provides 197 horsepower
• Turbocharged 4-stroke, inline 6 cylinder
• Full application approval by Deutz Corp.
• 12VDC battery system
• Low oil pressure shutdown
• High coolant temperature shutdown
• Intake air restriction indication
• Stop lever governing for precise control and longer life
• Electronic governor
• Fuel cooler system

Environmental

• Operation temperature:
     -25ºF to +125ºF
     -31ºC to +52ºC
• Relative humidity 0 - 100% non condensing
• No altitude derating required up to 5,000 feet, when running in normal operating range

Performance

• Rating: 120kVA, 96kW, 3 phase, 4 wire, 115/200 volt Wye, continuous
• Dual output (protected)
• Meets or exceeds MIL-STD-704E Electrical Power Quality Requirements

Overload

• 125% rated load for 5 minutes, 150% for 10 seconds
• Output: 324 amps, 5 minutes

Voltage

• Transient voltage recovery time: to within ±1% in 100 milliseconds (no load to rated load)
• Within ±20% deviation upon application/removal of 100% load rating
• Modulation: does not exceed 0.5% of steady state voltage
• Phase voltage displacement with balanced load: 120º ±1.5º
• Phase voltage balance with unbalanced load: does not exceed 4% with 1/3 rated current on any single phase with other two phases disconnected
• Crest factor: 1.414 ±0.07
• Individual Harmonic Distortion: < 2% of the fundamental (RMS) voltage
• Total Harmonic Distortion: < 3% of the fundamental (RMS) voltage

Regulation

• Voltage regulation: ±1% no load to full load
• Voltage adjust: ±15 volts
• Three phase average sensing, built-in line drop compensation, up to 5%

Frequency

• Regulation: ±2Hz steady state
• Transient recovery: to within ±0.5% (2Hz) in < 2 seconds
• Modulation: <0.25% (1Hz)

Protection

• Meets MILSTD-704E
• Overvoltage: instantaneous disconnection of load at 180 volts L-N, with inverse time delay down to 126 volts in 2 seconds
• Undervoltage: disconnects output below 100 volts L-N in 7 seconds
• Overfrequency: disconnects output above 420Hz in 5 seconds
• Underfrequency: disconnects output below 380Hz in 7 seconds

Finish

• Anti-corrosive powdered epoxy primer, electro statically applied to metal parts and sheet metal with Dupont Gloss white topcoat over black frame
• Resists glycol, skydrol and like corrosives

Displays/Instrumentation

Engine Operation

• Meters: coolant temperature, ammeter, hour meter, oil pressure, fuel level
• Indicator lights: engine circuit on, air cleaner restriction, high coolant temperature, low oil pressure, engine stop delay active, low fuel
• Switches: Engine start. engine stop, panel lights
• Delayed shutdown for turbocharger protection

Generator Output

• Meters: frequency, ammeter, voltmeter
• Indicator Lights: contactor(s) on, overfrequency, underfrequency, overload, overvoltage, undervoltage
• Switches: meter select, contactor(s), test/reset

Trailer

• Tire size: 20.5 x 8.00 - 10
• Ground clearance: 9" (.23m)
• Brakes: Tow bar activated, drum type

Options

• Noise reduction kit
• Glow plug starting aid
• Block heater kit (115V/6OHz or 240V/5OHz)
• Transformer-Rectifier pack for 28.5VDC
• Automatic towbar height stop
• Unit operating light
• Pintle or pin hitch
• Spot light
• Alternative mounting configuration: stationary/fixed or truck mounted
• Special paint scheme
• Hand activated brakes
• Battery blanket
• Indicator beacons

Gross Weight

• 6400 lbs. (2903 kg)

Specifications subject to change without notice.